This notice is to inform you that the South Coast Air Quality
Management District (District) is proposing to require, as best available control
technology (BACT), a Regenerative Thermal Oxidizer (RTO) to control volatile organic
compound (VOC) emissions from a proposed new CO2 Plant. The CO2 Plant will be located at
the Chevron Refinery, 324 W. El Segundo Blvd., El Segundo, CA 90245. However, the
equipment will be owned and operated by The BOC Group, Inc.
The District is the air pollution control agency for Orange County,
Riverside County (excluding the easternmost portion located in the Mojave Desert APCD) and
the non-desert portions of Los Angeles and San Bernardino Counties. Anyone wishing to
install or modify equipment that could control or be a source of air pollution within this
region must first obtain a permit from the District.
Pursuant to District Regulation XIII - "New Source Review",
the Executive Officer shall deny the Permit to Construct for any new or modified sources
which result in an emission increase of any nonattainment air contaminant, any ozone
depleting compound or ammonia, unless BACT is employed.
If uncontrolled, the new CO2 Plant vent will emit 10 lbs/day of VOC and
8 lbs/day of CO. The RTO control device will be required to reduce total hydrocarbon
emissions by at least 98% and CO to no more than 10 ppm. RTOs and other types of thermal
oxidizers are achieved in practice for many types of VOC emission sources and can be
applied by technology transfer to this source as well. (Because the the CO2 Plant uses a
waste stream from a hydrogen plant at Chevron Refinery as its feed material, the CO2 Plant
will reduce VOC emissions by about 300 lbs/day from the Chevron Refinery.)
Under the BACT Guidelines approved by the Governing Board on December
11, 1998, the District must distribute a public notice with a 30-day public comment period
when a new, more stringent BACT is required in a permit. This document serves as a notice
of the District’s intent to require control technology that would reduce total
hydrocarbon emissions by 98% as BACT for a new CO2 Plant vent.
Anyone wishing to comment on the proposed BACT determination for the
CO2 Plant should submit the comments in writing within 30 days of the distribution date
shown below. Submit written comments to Martin Kay, Planning, Rule Development & Area
Sources, South Coast Air Quality Management District, 21865 Copley Drive, Diamond Bar,
California 91765-4182 or by email to
